The use of hydrodynamic cavitation for waste-to-energy approach to enhance methane production from waste activated sludge

Zupanc, Mojca (avtor), Brajer Humar, Barbara (avtor), Dular, Matevž (avtor), Gostiša, Jurij (avtor), Hočevar, Marko (avtor), Kolbl Repinc, Sabina (avtor), Krzyk, Mario (avtor), Novak, Lovrenc (avtor), Ortar, Jernej (avtor), Pandur, Žiga (avtor), Stres, Blaž (avtor), Petkovšek, Martin (avtor)

Anaerobic digestion in wastewater treatment plants converts its unwanted end product – waste activated sludge into biogas. Even if the process is well established, pre-treatment of the sludge can further improve its efficiency. In this study, four treatment regimes for increasing methane production through prior sludge disintegration were investigated using lab-scale cavitation generator and real sludge samples. Three different cavitating (attached cavitation regime, developed cloud shedding cavitation regime and cavitation in a wake regime) and one non-cavitating regime at elevated static pressure were studied in detail for their effectiveness on physical and chemical properties of sludge samples. Volume-weighted mean diameter D[4,3] of sludge's particles decreased by up to 92%, specific surface area increased by up to 611%, while viscosity (at a shear rate of 3.0 s$^{−1}$) increased by up to 39% in the non-cavitating and decreased by up to 24% in all three cavitating regimes. Chemical changes were more pronounced in cavitating regimes, where released soluble chemical oxygen demand (sCOD) and increase of dissolved organic matter (DOM) compounds by up to 175% and 122% were achieved, respectively. Methane production increased in all four cases, with the highest increase of 70% corresponding to 312 mL CH$_4$ g$^{−1}$ COD. However, this treatment was not particularly efficient in terms of energy consumption. The best energy balance was found for the regime with a biochemical methane potential increase of 43%.

• Jezik: Angleški jezik
• Ključne besede: hydrodynamic cavitation, waste activated sludge, disintegration, viscosity, methane production, energy balance
• Vrsta gradiva: Članek v reviji
• Tipologija: 1.01 - Izvirni znanstveni članek
• Organizacija: FS - Fakulteta za strojništvo ; FGG - Fakulteta za gradbeništvo in geodezijo
• Status publikacije: Objavljeno
• Različica publikacije: Objavljena publikacija
• Leto izida: 2023
• Št. strani: 11 str.
• Številčenje: Vol. 347, art. 119074
• PID: 20.500.12556/RUL-151587
• UDK: 532.528
• ISSN pri članku: 0301-4797
• DOI: 10.1016/j.jenvman.2023.119074
• COBISS.SI-ID: 167876867
• Datum objave v RUL: 11.10.2023

Gradivo je del revije

• Naslov: Journal of environmental management
• Skrajšan naslov: J. environ. manag.
• Založnik: Elsevier
• ISSN: 0301-4797
• COBISS.SI-ID: 720405

Licence

• Licenca: CC BY-NC-ND 4.0, Creative Commons Priznanje avtorstva-Nekomercialno-Brez predelav 4.0 Mednarodna
• Povezava: http://creativecommons.org/licenses/by-nc-nd/4.0/deed.sl
• Opis: Najbolj omejujoča licenca Creative Commons. Uporabniki lahko prenesejo in delijo delo v nekomercialne namene in ga ne smejo uporabiti za nobene druge namene.

Sekundarni jezik

• Jezik: Slovenski jezik
• Ključne besede: hidrodinamska kavitacija, aktivno odpadno blato, dezintegracija, viskoznost, proizvodnja metana, energijska bilanca